卷帘门不正常运行的表现

随着科技的发展,电动卷帘门出现之后,给人们的生活是又有一大影响,但是,电动卷帘门在平时使用的时候会出现一些小故障,对此人们一定要做到多多的了解,以便能够做的好的处理,下面就来和济南电动卷帘门安装维修厂家一起看看卷帘门不正常运行的表现吧。

With the development of technology, the emergence of electric roller shutter doors has had another significant impact on people's lives. However, electric roller shutter doors may encounter some minor malfunctions during normal use. It is important for people to have a better understanding of this in order to handle it properly. Let's take a look at the abnormal operation of roller shutter doors with the installation and maintenance manufacturer of electric roller shutter doors in Jinan.

卷帘门不正常运行时，可能会出现以下表现：

When the roller shutter door is not operating properly, the following symptoms may occur:

1.卷帘门无法打开或关闭：可能是卷帘门在移动过程中遇到障碍物或者卷帘门设备出现故障，需要检查门体、滑轨和电机等部件是否有损坏或卡住。

1. The rolling shutter door cannot be opened or closed: It may be due to obstacles encountered during movement or malfunction of the rolling shutter equipment. It is necessary to check whether the door body, slide rails, and motor components are damaged or stuck.

2.卷帘门运行缓慢：可能是电机功率不足，或是滑轨上积聚了杂物，需要清理滑轨和检查电机工作情况。

2. The rolling shutter door runs slowly: it may be due to insufficient motor power or accumulation of debris on the slide rail, and it is necessary to clean the slide rail and check the operation of the motor.

3.卷帘门发出异常的噪音：可能是门体与滑轨之间的摩擦过大，或是设备出现故障，需要对门体和滑轨进行润滑和检查是否存在故障。

3. The rolling shutter door emits abnormal noise: it may be due to excessive friction between the door body and the sliding rail, or due to equipment failure. It is necessary to lubricate the door body and the sliding rail and check for any faults.

4.卷帘门上下摆动或晃动：可能是门体松动或滑轨不平整，需要检查门体和滑轨的连接处是否紧固和平整。

4. Rolling shutter door swinging or shaking up and down: It may be due to loose door body or uneven sliding rail. It is necessary to check whether the connection between the door body and the sliding rail is tight and flat.

5.卷帘门开启高度不够或超过规定高度：可能是设置高度限制的开关出现问题，需要检查调整开关的位置和灵敏度。

5. The opening height of the roller shutter door is not enough or exceeds the specified height: It may be due to a problem with the switch that sets the height limit. It is necessary to check and adjust the position and sensitivity of the switch.

电动卷帘门常见故障怎么维修?

How to repair common faults of electric roller shutter doors?

1、当电动卷帘门无法启动或者是启动较慢的时候。我们首先要检查电动机是否能够正常运行工作,若不能则更换电动机。然后检查机械部分有没有卡住的地方,有的话就清除掉即可。

1. When the electric roller shutter door cannot be started or starts slowly. We first need to check whether the motor can operate normally, and if not, replace the motor. Then check if there are any stuck areas in the mechanical part, and if so, remove them.

2、当出现控制器失效时,我们首先应该更换电源接触器,然后更换传动齿轮。当出现电动机震动频率过大,噪声过大时。先应检查轴承是否老化,然后检查滑动轮是否需要添加润滑油等。检查电动机是否损坏。

2. When the controller fails, we should first replace the power contactor and then replace the transmission gear. When there is excessive vibration frequency and noise of the motor. First, check if the bearings are aging, and then check if the sliding wheels need to be lubricated. Check if the motor is damaged.

3、要提醒大家的是,滑动轮和驱动器一年至少要添加一次润滑油,传动皮带一年要进行一次检修,还有定时检查各部件的磨损情况。

3. It should be reminded that the sliding wheel and driver should be lubricated at least once a year, the transmission belt should be inspected once a year, and the wear of each component should be checked regularly.

以上是卷帘门不正常运行的一些表现，不同的表现可能由不同的原因引起，如果卷帘门出现故障需要及时进行检修和维护，以保证卷帘门的正常运行。如果自行检修无法解决问题，建议联系专业服务人员进行检修和维护。您还有什么需求可以随时来我们网站http://www.jnyuqilin.com咨询！

The above are some manifestations of abnormal operation of the roller shutter door, which may be caused by different reasons. If the roller shutter door malfunctions, timely maintenance and repair are required to ensure the normal operation of the roller shutter door. If self inspection cannot solve the problem, it is recommended to contact professional service personnel for inspection and maintenance. If you have any further needs, please feel free to come to our website at any time http://www.jnyuqilin.com consulting service