防火卷帘门的维修标准章程详解

随着社会经济的发展，防火卷帘门的应用已经很是普遍了，很多人对于防火卷帘门的维修也是很关注，下面济南防火卷帘门安装维修厂家为大家介绍防火卷帘门的维修标准。

With the development of social economy, the application of fire rolling shutter doors has become very common, and many people are also concerned about the maintenance of fire rolling shutter doors. Now, the Jinan fire rolling shutter door installation and maintenance manufacturer will introduce the maintenance standards of fire rolling shutter doors.

1．适用范围：大厦内防火分区、地下停车场用防火卷帘门的保养。

1. Scope of application: maintenance of fire compartment and fire rolling shutter doors for underground parking lot in the building.

2．引用标准：无。

2. Reference standards: None.

3．日常保养：

3. Daily maintenance:

周期：月

Period: month

外观检查门轨、门扇有无变形、卡阻现象；操作按钮箱是否良好上锁。

Visually check the door rail and door leaf for deformation and jamming; Whether the operation button box is locked properly.

检查防火卷帘门电控箱指示灯是否正常，箱体有否受损。

Check whether the indicator of the electric cabinet of the fire shutter door is normal and whether the cabinet is damaged.

开启按钮，按下上（或下）按钮，卷帘门应上升（或下降）如果卷帘门升降与按钮操作上下不一样，要立即停车，修复后方可重新操作。

Open the button, press the up (or down) button, and the rolling shutter door shall rise (or fall). If the lifting of the rolling shutter door is different from the up and down operation of the button, stop the vehicle immediately, and operate it again after repair.

在按钮操作上升（或下降）过程中，操作人员严禁离开现场，操作的同时，要密切注意帘门上升（或下降）到一定位置之后地否能自动停车。如果帘门上升到位后（或下降已到地面）仍不停，一定要待限位装置修复（或调整）正常后方可重新操作。

In the process of button operation rising (or falling), the operator is strictly prohibited from leaving the site. While operating, pay close attention to whether the curtain door can automatically stop after rising (or falling) to a certain position. If the curtain door still does not stop after it is lifted to the right position (or lowered to the ground), it must not be operated again until the limit device is repaired (or adjusted) normally.

二次下滑关闭后，待探测器信号消除后方可重新开启帘门。

After the second sliding closing, the curtain door can be reopened after the detector signal is eliminated.

做好保洁工作，清扫电机、控制箱等外表灰尘。

Clean the motor, control box and other surfaces.

在以上保养中出现异常问题时，应在当天予以纠正，保证系统正常。

If abnormal problems occur during the above maintenance, they should be corrected on the same day to ensure the system is normal.

4．一级保养

4. First level maintenance

周期：季

Period: quarter

完成月保养的内容

Complete the monthly maintenance

双探测器（门两侧分装）或单探测器（门一侧安装）任一烟感或温感动作时，将自动启动装置，装置发出报警声，同时自动启动帘门电控系统，如防火卷帘门做防火分区用，则一次下滑到底；如防火卷帘门兼做逃生口用，则两次下滑关闭防火卷帘门（防火卷帘门一次下滑至离地面1.8米左右停止，延时三十秒左右，二次再自动下行关闭）。

In case of any smoke or temperature sensing action of double detectors (separately installed on both sides of the door) or single detectors (installed on one side of the door), the device will automatically start, the device will give an alarm sound, and the electric control system of the shutter will automatically start. If the fire shutter door is used as a fire compartment, it will slide down to the bottom at one time; If the fire rolling shutter door is also used as an escape exit, the fire rolling shutter door will be closed by sliding down twice (the fire rolling shutter door will stop when it slides down to about 1.8 meters above the ground once, delaying about 30 seconds, and it will be closed automatically when it slides down again twice).

消防中心遥控检查。

Remote control inspection of fire control center.

操作按钮下滑关闭帘门，关闭到位将有信号反馈到消防中心显示。紧固各部分镙钉及联轴。

The operation button slides down to close the curtain door. When it is closed in place, a signal will be fed back to the fire center for display. Fasten all screws and couplings.

绝缘电阻应符合规定。

The insulation resistance shall meet the requirements.

5．二级保养：

5. Secondary maintenance:

周期：年

Period: years

完成一级保养的内容。

Complete the first level maintenance.

整体检查，对局部变形及油漆脱落现象进行修复。

Conduct overall inspection and repair local deformation and paint peeling.

逐一检查控制箱内各按钮及元件是否正常。

Check whether the buttons and elements in the control box are normal one by one.

调整电机传动皮带的松紧度。

Adjust the tightness of the motor drive belt.

向防火卷帘门的转动部位填加润滑油，以保证联轴器及轴承的灵活性及稳定性。

Add lubricating oil to the rotating part of the fire shutter door to ensure the flexibility and stability of the coupling and bearing.

对检查发现的缺陷逐一修复。

Repair the defects found in the inspection one by one.

相关文件及记录，消防设备保养表。

Relevant documents and records, fire equipment maintenance sheet.

防火卷帘门的维修标准大致就是如此了，这可以算是一个章程，大家可以根据上述的内容进行防火卷帘门的维修，值得注意的是，大家一定要进行定期的检查，千万不要疏忽了。更多相关内容来我们网站http://www.jnyuqilin.com咨询吧！

The maintenance standard of the fireproof rolling shutter door is roughly like this, which can be regarded as a regulation. You can carry out the maintenance of the fireproof rolling shutter door according to the above contents. It is worth noting that you must carry out regular inspection and never neglect it. Come to our website for more information http://www.jnyuqilin.com Consult!